专注通风管道加工·排烟罩

1、 Inspection before operation of oil fume purifier:

1、该设备必须专人负责，操作，维修及保养；

1. The equipment must be operated, repaired and maintained by special personnel;

2、操作人员需进行培训，获得上岗证必须持证上岗，并学习油烟净化器《使用说明书》，了解该设备的基本结构和性能，熟练掌握操作规程，并严格按照操作规程进行操作；

2. Operators shall receive safety training, obtain work license and work with certificate, and learn the Operation Manual of the fume purifier, understand the basic structure and performance of the equipment, master the operating procedures, and operate in strict accordance with the operating procedures;

3、油烟净化器用电量大，为防止导线超负荷，须采用单独线路供电，同时安装合适的熔断器和使用耐高温的绝缘材料并加装漏电保护器；

3. The oil fume purifier consumes a large amount of electricity. In order to prevent the overload of the conductor, it is necessary to use a separate line for power supply, and at the same time, install appropriate fuses, use high-temperature insulation materials and install leakage protectors;

4、开机前应认真点检设备防护装置是否良好，设备接地线是否牢固，电源系统及舱门是否关闭是否密封良好；排油管是否接好；

4. Before starting the machine, carefully check whether the safety protection device of the equipment is in good condition, whether the grounding wire of the equipment is firm, and whether the power supply system and cabin door are closed and sealed; Whether the oil drain pipe is connected properly;

5、确认输入电压与设备使用电压是否匹配；

5. Confirm whether the input voltage matches the equipment use voltage;

6、为确保，油烟净化器要求能与风机联动，及净化器跟风机同时开同时关；如不能联动的，应做到启动净化器之前必须先启动风机运行10分钟；（特别是在北方严寒的冬天，风机先启动的时间应该，关机时应先关掉净化器后再停风机；

6. To ensure safety, the oil fume purifier is required to be linked with the fan, and the purifier and the fan are opened and closed at the same time; If linkage is not possible, the fan must be started for 10 minutes before starting the purifier; (Especially in the cold winter in the north, the fan should be started first, and the purifier should be turned off before the fan is shut down;

7、油烟净化器与烟罩出口位置的距离少2米以上，以确保消防和净化效果；净化器与风机的距离4米以上比较合适；

7. The distance between the oil fume purifier and the outlet of the hood shall be at least 2 meters to ensure the fire safety and purification effect; The distance between purifier and fan is more than 4 meters;

二、油烟净化器操作程序：

2、 Operating procedures of oil fume purifier:

1、完成通电前检查正常后，开启风机电源控制开关，当净化器电源批示箱，绿灯亮时，表示净化器已开始正常运转工作；

1. Turn on the fan power control switch after completing the check before power-on. When the green light in the purifier power instruction box is on, it means that the purifier has started normal operation;

2、如启动后，若红灯偶尔有闪烁，表示电极间有放电现象，属正常现象；

2. If the red light flashes occasionally after starting, it means that there is discharge between electrodes, which is normal;

3、若红灯长时间亮着，表示不工作，可按动电箱复位键多次，如绿灯亮时，表示已恢复正常工作；

3. If the red light is on for a long time, it means that it does not work. You can press the reset button of the electric box several times. If the green light is on, it means that it has resumed normal work;

4、如红灯长时间亮着，按动复位键多次亦未转绿灯，应关闭电源，重新检查电极控制电路，确定无误后，再次启动电源开关。如反复操作红灯亮时，则再次关闭电源开关，对高压电极进行检杳，清洗，同时亦可联系维修技术人员及进检修；

4. If the red light is on for a long time, and the reset button is pressed several times without turning green, the power should be turned off, the electrode control circuit should be rechecked, and the power switch should be started again after confirming that there is no error. If the red light is on after repeated operation, turn off the power switch again, check and clean the high-voltage electrode, and also contact professional maintenance technicians for maintenance;

三、油烟净化器运行使用注意事项：

3、 Precautions for operation and use of oil fume purifier:

1、由于油烟净化器内属高压系统，严禁设备在通电的工作状态下，打开电极舱门和电控箱门，以及触摸设备内一切系统部件；

1. Since the oil fume purifier is a high-voltage system, it is strictly prohibited to open the electrode cabin door and the electric control cabinet door, and touch all system components in the equipment when the equipment is powered on;

2、严禁任何异物进入设备电极系统内；

2. No foreign matter is allowed to enter the electrode system of the equipment;

3、设备箱体必须接地；

3. The equipment box must be grounded safely;

4、本设备不允许非人员拆装及检修，若发生故障时，应及时关闭电源，由人员进行检修；

4. The equipment is not allowed to be disassembled and repaired by non-professional personnel. In case of failure, the power supply shall be turned off in time and the equipment shall be repaired by professional personnel;

5、油烟净化器使用2~3个月内，必须对设备进行清洗、保养、否则出现故障导致影响处理效率；

5. The oil fume purifier must be cleaned and maintained within 2~3 months of use, otherwise the failure will affect the treatment efficiency;